Having problems with your Vacuums ?

DIRT DEVIL MADEL 08245 BRUSE DOSEN'T ROTATE


Answers :

I had the same problem and fixed it to where it would work OK, althought not 100%. 1. Disconnect the hose that goes to the roller brush area. 2. Press the button right below the power switch while sliding the handle what ever direction it will go to release it from the body of the vac. 3. Remove 3 screws from the handle halves. 4. Remove 2 screws from a keyed black plastic piece that hold the handle halves together. 5. Carefully separate the handles halves from the clear plastic piece in the center that allows you to view the brush and belt. 6. If the belt is broken or missing, replace it and reassemble, if the belt is OK, remove the roller and test if the bearings spin freely. 7. If they don't, then remove the clip or clips of each end that hold the bearing(s) in place. (Work in a controlled environment so that when the little clip goes flying you'll be able to locate it without moving the refridgerator.) 8. Clean the back side of the bearing of hair, dust and dirt. (used compressed air if you have it) 9. Reassemble the bearing(s) you removed and cleaned on each end of the roller. I used a spritz of teflon dry lube spray on each when I put them back together. 10. Disassemble the air motor bearing from the shaft on the end that does not have the belt gear. Be careful not to lose the flat thrust bearing/washer at the bottom of the bearing housing. Clean, lube and reassemble. 11. Since I felt I couldn't remove the belt gear from the shaft (to get at the bearing), without damaging it, I worked at cutting the hairs and threads wound around the shaft. I used a single edge razor blade to painstakingly cut and remove what I could, then lubed and reassembled air motor. 12. I then reassembled everything and tried it. IT WORKED. The still sluggish bearing on the gear end of the air motor wasn't enough to stop the motor from turning the brush at an acceptable speed and torque.
Http://www.geeksquad.fixya.com/ThreadView.aspx?prdid=0&thid=559809
\015\012Generic problem for all Vacuums
\015\012DIRT DEVIL MADEL 08245 BRUSE DOSEN'T
\015\012Posted by GENEFIXIT on Apr 30, 2008
\015\012DIRT DEVIL MADEL 08245
BRUSE DOSEN'T ROTATE
\015\012
\015\012DIRT DEVIL MODEL 08245
BRUSE HAS NO TORQUE, HOW DO I OPEN UNIT TO GET TO TURBO UNIT

\015\012
\015\012Hello,
\015\012I would advise you to ALWAYS to FIRST UNPLUG YOUR VACUUM before beginning any service procedure.
\015\012As per the brush does not rotate you may have a broken belt and it would need a new one. Also make sure the brushroll is clean and spins freely and free from thread, hair and other types of things that get wrapped around the brushroll. The recommended belt change id every 4 to 6 months if you have a flat belt.
\015\012Most of the turbo units are a snap together or they have hidden screws to un-screw to open the top and the bottom of the turbo unit, please check with you owner’s manual under trouble shooting and they will instruct you on how to dis-assemble the unit, and also please check with your local vac dealer. So if you need further assistance, please feel free to contact your local vacuum cleaner dealer in your area or in the yellow pages, or contact the factory phone number or website to further assist you with your questions.
\015\012http://www.royalvacuums.com
\015\012Customer Service
\015\012For help with a model that is not working, if you want to check an order, if you need help finding a part or service center or have any other comment, complaint or question that is not a technical question about this web site use the link above. You can also call our Customer Service department between 8AM and 7PM EST Monday through Friday at (800) 321-1134.
\015\012Don – The Vac Man
\015\012Go Ahead. Use Us.
Repair Help & Product Troubleshooting for Vacuums

Tips for a great answer:

- Provide details, support with references or personal experience .
- If you need clarification, ask it in the comment box .
- It's 100% free, no registration required.

Suggested Questions/Answers :

DIRT DEVIL MADEL 08245 BRUSE DOSEN'T ROTATE


I had the same problem and fixed it to where it would work OK, althought not 100%. 1. Disconnect the hose that goes to the roller brush area. 2. Press the button right below the power switch while sliding the handle what ever direction it will go to ... Vacuums

I have dirt devil envision M086710 less than a year and rotating brush does not work ? 'everything works except suction from rotating brush ..


... Dirt Devil CE5500 Floor Keeper Upright Wet/Dry Vacuum

Rotating brush is not rotating - Dirt Devil Featherlite Bagless Upright Vacuum


... Dirt Devil Featherlite Bagless Upright Vacuum

Dirt Devil- Brush not rotating on its own. No suction.


Drive belt. take housing apart (draw a diagram so you can put it back together) take the broken belt to a vacuum repair shop to get the same one. mine cost 7$.\015\012\015\01215 minutes work. ... Dirt Devil Featherlite Bagless Vacuum M085845Vacuum

Hi, The belt of our Dirt devil bagless vaccum broke and we got new belt and replaced it. Even after replacing the belt, the brush is not rotating. Any suggestions please ?


Did you check to see that the beater brush, the brush that the belt drives, is free of debris and moves freely?\015\012When they bind up they can cause the belt to break.\015\012Remove the beater brush just as you do when changing the belt and clean ... Dirt Devil Featherlite Bagless Vacuum M085845Vacuum

Brush doesn't rotate - Dirt Devil MVP Swivel Glide M0820 Handheld Vacuum


Check if belt is broken.... ... Dirt Devil MVP Swivel Glide M0820 Handheld Vacuum

The brushroll on my dirt devil (vax X3) was caught o the curtain, and now the reset button will not reset the brush. the power comes on for the brush, but the brush will not rotate. What can i di to fix this problem


I didn't find the reset button until I took all the screws out and then couldn't separate it. Good luck! ... VAX Appliances Vax X3 Bagless Upright Vacuum

Dirt devil easy lite trouble shooting help needed! Our Dirt Devil doesn't pick up now and has dirt/dust kicking up as I vacuum. It behaves like a dirt devil spreader instead!


... Dirt Devil Easy Lite Quick Vacuum

My dirt devil model # 086925 it's picking up dirt, and it's not


... Dirt Devil Vacuums

How to close dirt cup on 10 amp dirt devil 10 AMP dirt devil power air cyclone vac


Go here.> http://dirtdevil.com/search/?q=UD40135&type=3 click on your vac then you can download the manual ... Vacuums

Dirt Devil Ultra: grinding noise, burning smell,brush not turning


This sounds like the motor went out ... Vacuums

Replace belt on dirt devil vision - Dirt Devil Vision Turbo W/Bonus Upright Vacuum Vacuum


... Dirt Devil Vision Turbo W/Bonus Upright Vacuum Vacuum

Dirt devil owners manual - Dirt Devil Classic M08100 Bagged Handheld Vacuum


... Dirt Devil Classic M08100 Bagged Handheld Vacuum

Dirt devil blows hot air brand new - Dirt Devil 12 Amp HEPA Filter Vacuum Vacuum


... Dirt Devil 12 Amp HEPA Filter Vacuum Vacuum

How do I remove the dust container safely? The Dirt Devil was given to me with no instructions when friends moved away. I do not want to break it. It is Dirt Devil HEPA.


... Dirt Devil 12 Amp HEPA Filter Vacuum Vacuum

How do i put a belt on my dirt devil vision - Dirt Devil M086700 Vision Bagless Upright Vacuum


Without the model number I cannot give you a link to the exact manual that will have a step by step process for user maintainable items like belts. However if you click the link below and enter your model number at the prompt you should be able to d ... Dirt Devil M086700 Vision Bagless Upright Vacuum

How to replace wheel bracket on dirt devil. I have a dirt devil swivel glide and I took off the wheel bracket to clean out a clog and now I cant seem to get the wheel bracket back on.


... Dirt Devil SwivelGlide Bagged Upright Vacuum

I need the dirt devil floorkeeper manual. - Dirt Devil CE5500 Floor Keeper Upright Wet/Dry Vacuum


... Dirt Devil CE5500 Floor Keeper Upright Wet/Dry Vacuum

How do i make my dirt devil blow air - Dirt Devil Featherlite Bagless Vacuum M085845Vacuum


... Dirt Devil Featherlite Bagless Vacuum M085845Vacuum

I need to find a Clean Water Tank Assembly for a dirt devil platinum force Model Number: MCE7900. Any suggestions? I'm trying to find it cheaper than on the dirt devil web site.


Check your local vacuum stores. I don't know if you'll get one cheaper, but they mat be able to supply a good used one and save you a few bucks. ... Vacuums

Change belt on dirt devil vacuum - Dirt Devil Vacuums


It largely depends on the model you have. However, you can get any Dirt Devil replacement belt here:Dirt Devil Belts ... Dirt Devil Vacuums

My dirt devil vacuum cleaner is not working - Dirt Devil M130000 ''i'' Dual Cyclonic Upright Vacuum Cleaner Vacuum


Please specify whether the vacuum motor does not turn on when you flip the switch or it simply does not have suction. ... Dirt Devil M130000 ''i'' Dual Cyclonic Upright Vacuum Cleaner Vacuum

DIRT DEVIL VACUUM 4 MONTH OLD AND HOSE SPLIT TOOK BACK TO ARGOS TRIED TO INFER IT WAS MY FAULT ENYONE HAD THIS PROBLEM ? THE STRETCH HOSE SPLIT AND I HAVE NOT HAD THIS HAPPEN WITH ENY OTHER CLEANER THE SALES GIRL IN ARGOS SAYS THIS WAS MY FAULT . DIRT DEVIL VACUUM DDCYLBG5 BAGGED CYLINDER G TABERN.


From the Argos website... they must repair or replace or refund, up to 1 year. The squeaky wheel gets the grease, go over her head.\015\012 \015\012If there's a fault with the product...\015\012We've made it easier!\015\012 ... Vacuums

Dirt devil ce7300 won't dispense solution - Dirt Devil Easy Steamer Upright Wet/Dry Vacuum


... Dirt Devil Easy Steamer Upright Wet/Dry Vacuum

I have a dirt devil that is only 2 years old, I used it and sparks began to shoot out from the front grill area. I called dirt devil's corporate office at 12noon today July 25th, and was told that with out my receipt there was nothing that could be done and since I only paid $39 for the cleaner I should just get another one. This product is a fire hazard!!!!!!!! I was vacuming near my bed when the sparks began, I find it unbelievable that this was taken so lightly. If my home had burned d


... Dirt Devil Vacuums
  • Start your question with What, Why, How, When, etc. and end with a "?"
  • Be clear and specific
  • Use proper spelling and grammar
all rights reserved to the respective owners || www.mictaservice.com || Terms of Use || Contact || Privacy Policy
Load time: 0.0269 seconds